All-power APG3590CN Uživatelský manuál

APG3590CN

10000W Propane Generator General Precautions (cont’d)Personal Safety (cont’d) • Avoid accidental starting. Make sure the power switch is in its “OFF

Owner’s ManualGeneral Precautions (cont’d)ServicingMaintain labels and name plates on the generator and engine. These carry important information. If

1210000W Propane Generator General Precautions (cont’d)Installation (cont’d) • If the generator is installed outdoors, it must be weather

Owner’s ManualGeneral Precautions (cont’d)Mechanical (cont’d) • Do not operate the generator with safety guards removed. While the generator is runnin

Nameplate Amps(@ full load) Cord Lengths0ft.-50ft. 50ft.-100ft. 100ft.-150ft. 150ft.-200ft.10000W Propane GeneratorGeneral Precautions (cont’d)Extensi

15AssemblyWheel and handle assembly:1) CONTENTS: Spark plug Tool + Rod, 2 axles, 2 washers, 4 cotter pins, 2 wheels, Stand, 4 bolts 4 nuts,

16AssemblyWheel and handle assembly:7) Handles should be already installed.8) Twist and pull out to use handles. 10000W Propane Generator

To start generator with electric start you will need a battery (included). You can also use a 12v lawn tractor battery with the following specificat

WARNINGDO NOT OPERATE THE GENERATOR IN ENCLOSED SPACES, GARAGES, BASEMENTS, CRAWL SPACES AND OTHER LOCATIONS WHERE CARBON MONOXIDE GAS CAN COLLECT AND

2010000W Propane Generator Operation (cont’d)Starting InstructionsConnect the propane hose from thepropane tank to the machineMove the choke lever t

21Owner’s ManualOperation (cont’d)Starting InstructionsMove the choke lever to the "RUN"position.Battery Start: If battery is installed, tur

2210000W Propane Generator Operation (cont’d)Powering 120 Volt AC Tools And Equipment: 1. Prior to powering tools and equipment, make sure the gener

Powering 120/240 Volt AC Tools And Equipment:Operation (cont’d)Owner’s Manual 1. Prior to powering tools and equipment, make sure the generator’s rate

1. Remove the spark plug cap.24In order to service the spark plug,you will need a spark plug wrench (commercially available).Recommended spark plugs:

25Owner’s ManualInspection, Cleaning, and Maintenance WARNING! ALWAYS MAKE SURE THE ENGINE POWER SWITCH IS IN ITS “OFF” POSITION. DISCONNECT THE

26Installation NOTE: PRIOR TO POWERING TOOLS AND EQUIPMENT MAKE SURE THE GENERATOR’S RATED VOLTAGE, WATTAGE AND AMPERAGE CAPACITY IS ADEQUATE T

27Installation (cont’d)Supporting and Mounting Mount the generator on a concrete slab capable of supporting the weight of the generator. The slab must

Engine

10,000W Propane Generator29APA PART NO.DESCRIPTIONPART NO.ACylinder head system assy. APG3590CN-A-01-JD HEAD COVER COMP. BOLT JF340-A-01APG3

Limited WarrantyAll-Power America warrants to the original purchaser who uses the product in a consumerapplication (personal, residential or household

30BAPG3590CN-B-01-JD FLANGE BOLT (M6X 14) JF340-B-01 APG3590CN-B-02-JD OIL LEVEL SWITCH ASSY. JF240-B-02APG3590CN-B

31nCCrankcase cover system assy. 10,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-C-01-JD DUCT COVER JD5000-A-01APG3590CN

Crankshaft assy. 32DAPG3590CN-D-01-JD CRANKSHAFT COMP. JF420-D-02 APG3590CN-D-02-JD BALANCER WEIGHT JF340-D-04

Piston & Connecting Rod Assy. 33E10,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-E-01-JD COMPRESSION RING A JF420-E-

Recoil Starter Assy.34F10,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-F-01-JD PIVOT ADJUSTING NUT JF340-F-01APG3590CN-F-

Recoil Starter Assy. 35G 110,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-G-01-JD RECOIL STARTER ASSY. JF340-G-01APG3590CN

Fan Cover Assy. 36H 10,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-H-01-JD SHROUD JF340-H-01APG3590CN-H-02-JD F

Carburetor Assy.3610,000W Propane GeneratorAPA PART NO.DESCRIPTIONPART NO.APG3590CN-I-01-JD TUBE CLIP JF3800-B-01APG3590CN-I-02-JD

Flywheel Assy. 38J543210,000W Propane GeneratorAPA PART NO. DESCRIPTION PART NO.APG3590CN-J-01-JD FLYWHEEL JF340E-J-01APG3590CN-J-02-JD

Ignition System Assy. 39K788910,000W Propane GeneratorAPA PART NO. DESCRIPTION PART NO.APG3590CN-K-01-JD NOISE SUPPERSSOR CAP ASSY. JF340-K-0

Limited Warranty (cont’d)THIS WARRANTY DOES NOT COVER:• Merchandise sold as reconditioned,used as rental equipment,or floor or display models.• Mercha

Starter Motor Assy. 40LAPG3590CN-L-01-JD UNIT STARTER MOTOR JF340-L-01APG3590CN-L-02-JD CONTACTOR ASSY.

Control Assy. 41MAPG3590CN-M-01-JD CONTROL ASSY. JF340-M-01B APG3590CN-M-02-JD CONTROL BASE COMP. JF340-M-02B APG359

Muffler Assy.42N APG3590CN-N-01-JD FLANGE BOLT (M8 X 16) JD3800-B-01 APG3590CN-N-02-JD FLANGE BOLT (M6 X 12)

Air Cleaner43OAPG3590CN-O-01-JD AIR CLEANER COVER COMP JD3800-C-01 APG3590CN-O-02-JD AIR CLEANER ELEMENT JD3800-

PART NO.10,000W Propane GeneratorAPG3590CN-Q-01 -JDAPG3590CN-Q-02 -JDAPG3590CN-Q-03 -JDAPG3590CN-Q-04 -JDAPG3590CN-Q-05 -JDAPG3590CN-Q-06 -JDAPG3590CN

Frame Comp Assy. 45R10,000W Propane GeneratorAPA PART NO. DESCRIPTION PART NO.APG3590CN-R-01-JD FRAME COMP. JD6500ELPG-B-01APG3590CN-R-

Generator46SAPG3590CN-S-01-JD STATOR COVER JD8000-D-01 APG3590CN-S-02-JD STATORASSY. JD8000-D-02 APG3590CN-S-03-

Generator47APG3590CN-S-18-JD HEX.BOLT (M5 X 20) JD3800-G-18APG3590CN-S-19-JD VOLT CHANGE TERMINAL BR-AC-W JD3800-G-19APG3

Wheel & Handle Assy.48T41 097651234321111 0976581 0911APG3590CN-T-01-JD COTTER PIN JD6500-T-01 APG3590CN-T-02-JD PLAIN W

Owner’s ManualSafety Guidelines-DefinitionsSave These Important Safety Instructions!This manual contains important information that you need to know a

610000W Propane Generator Fuel and OilThis product requires oil and fuel. Attempting to start the engine without oil will ruin the engine and void t

Owner’s Manual 7General Precautions (cont’d)Fuel and Oil (cont’d) • Do not smoke, or allow sparks, flames or other sources of ignition around

810000W Propane Generator General Precautions (cont’d)Work Area • Keep your work area clean and well lit. Cluttered benches and dark areas invite ac

9Owner’s ManualGeneral Precautions (cont’d)Electrical Safety (cont’d) • All connections and conduits from the generator to the load must only be insta